Jeep WRANGLER B7659 User Manual

Please read this manual and save it with your original sales receipt.Tools needed for assembly: Phillips Screwdriver, Hammer, Pliers and Safety Scisso

10DashKey Assembly•Insert and “snap” the key assembly into the opening inthe dash, as shown.Dash ViewSteeringColumnHoleBottom View• Wipe the steering

11• Fit the wide notch in the side of a headlight lens underthe wide tab on a lens guard.• Press firmly on the inside of the headlight lens to snap it

12Assembly•Position the windshield so that the wipers face the frontend of the vehicle.•Insert and “snap” the two large tabs on the windshieldinto the

13•Turn the seat upside down.•Insert the fastener end of a short seat belt strap throughthe slot near the outer edge of the seat. Make sure theside of

14• Fit a support to one side of the sport bar.• Insert a #8- 32 x 1.625"screw through the support, thesport bar and out through the support.• Fi

•Fit the sport bar into the holes in the vehicle body.• Push down firmly on a sport bar support while pulling up on the side fender to fit the sport b

16Label DecorationGProper label application will help to keep the labels looking their best! When applying labels, keep the followingguidelines in min

17Label DecorationLeft Side View2526513431011112472929292930303030Right Side View42727

18Battery InstallationHIMPORTANT! Use only a Power Wheels®12 volt battery.Use of any other battery will damage your vehicle. Makesure that you charge

19Battery Care and DisposalIIf a battery leak develops, avoid contact with the leakingacid and place the damaged battery in a plastic bag. Pleaserefer

2Table of ContentsImportant InformationA Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Use vehicle on generally level ground ONLY!Rules for Safe DrivingJTeach Safety Rules to ChildrenWhile children can quickly develop the skill necessary

21How to Operate Your VehicleK• Make sure the shifter is in the low speed position .• Press down on the foot pedal . The vehicle goes forwardat a maxi

22To DriveCaring For Your VehicleLAdvanced Use - High Speed Drive• Check all screws, cap nuts and protective coveringsregularly and tighten as require

23Problems and Solutions GuideIMPORTANT! If you experience a problem with your vehicle, first check the Problems and SolutionsGuide below. If you stil

24Problems and Solutions GuideShort run time (Less than Undercharged battery Charge the battery. A new battery should have been1 - 3 hours per charge

25If, after reviewing the Problems and Solutions Guide, the vehicle still fails to operate, please contact your nearest authorized service center or c

26*One year limited warranty from the date of purchase on the Power Wheels®vehicle.Six month limited warranty on the 12 volt battery.For the original

27

PRINTED IN MEXICO B7659pr-0920IMPORTANT!DO NOT use this vehicle for the first time until you havecharged the battery for 18 hours.Remember to…✔Charge

CAUTIONWARNINGWARNING• Battery can fall out and injure a child if vehicle tips over. Always use battery clamp.• PREVENT FIRE- Never modify the electri

4PartsC• If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather thanreturn this product to the

5PartsHood Latch – 2Key Assembly#8 x 1" Screw – 7#10 x 1" Screw – 7Windshield Sport Bar Not Shown: Label SheetSteering ColumnAll Shown Actua

61Vehicle Body 12Steering Column 13 .354 Cap Nut 24 Hood Latch 25 12 Volt Battery 16Battery Clamp Unit 17Key Assembly 18Taillight Lens 29 Taillight H

CAUTIONUse the charger in dry locations only.WARNING7About Thermal FusesYour Power Wheels®12 volt battery is equipped with abuilt-in thermal fuse. The

WARNING8Children can be harmed by small parts,sharp edges and sharp points in thevehicle’s unassembled state, or by electricalitems. Care should be ta

921BatteryCompartmentDash•Position the dash on the vehicle body.• Make sure the motor harness connector wire is throughthe groove in the dash.•Insert